Effect of cell shape on nonlinear electrophoresis migration.

This study contributes to the renewed interest in the study of nonlinear electrophoresis of colloidal particles. In this work the influence of cell shape on electrophoretic migration under the nonlinear regimes of moderate and strong field regimes was assessed. Four types of bacterial and yeast cells (one spherical, three non-spherical) were studied and their electrophoretic mobilities for the moderate and strong electric field magnitude regimes were estimated experimentally. The parameter of sphericity was employed to assess the effect cell shape on the nonlinear electrophoresis migration velocity and corresponding mobility under the two electric field magnitude regimes studied. As particle migration under nonlinear electrophoresis depends on particle size and shape, the results in terms of mobilities of nonlinear electrophoresis were presented as function of cell hydrodynamic diameter and sphericity. The results indicated that the magnitude of the mobilities of nonlinear electrophoresis for cells increase with increasing cell size and increase with increasing deviations from spherical shape, which is indicated by lower sphericity values. The results presented here are the very first assessment of the two types of mobilities of nonlinear electrophoresis of cells as a function of size and shape.

Fine-Tuning the Characteristic of the Applied Potential To Improve AC-iEK Separations of Microparticles.

There is an immediate need for the development of rapid and reliable methods for microparticle and cell assessments, and electrokinetic (EK) phenomena can be exploited to meet that need in a low cost and label-free fashion. The present study combines modeling and experimentation to separate a binary mixture of microparticles of the same size (5.1 µm), shape (spherical), and substrate material (polystyrene), but with a difference in particle zeta potentials of only ∼14 mV, by applying direct current (DC)-biased low-frequency alternating current (AC) voltages in an insulator-based-EK (iEK) system. Four distinct separations were carried out to systematically study the effect of fine-tuning each of the three main characteristics of the applied voltage: frequency, amplitude, and DC bias. The results indicate that fine-tuning each parameter improved the separation from an initial separation resolution Rs = 0.5 to a final resolution Rs = 3.1 of the fully fine-tuned separation. The separation method exhibited fair reproducibility in retention time with variations ranging from 6 to 26% between experimental repetitions. The present study demonstrates the potential to extend the limits of iEK systems coupled with carefully fine-tuned DC-biased low-frequency AC voltages to perform discriminatory micron-sized particle separations.

Characterization of the Nonlinear Electrophoretic Behavior of Colloidal Particles in a Microfluidic Channel.

Contemporary findings in the field of insulator-based electrokinetics have demonstrated that in systems under the influence of direct current (DC) fields, dielectrophoresis (DEP) is not the main electrokinetic mechanism responsible for particle manipulation but rather the sum of electroosmosis, linear and nonlinear electrophoresis. Recent microfluidic studies have brought forth a methodology capable of experimentally estimating the nonlinear electrophoretic mobility of colloidal particles. This methodology, however, is limited to particles that fit two conditions: (i) the particle charge has the same sign as the channel wall charge and (ii) the magnitude of the particle ζ-potential is lower than that of the channel wall. The present work aims to expand upon this methodology by including particles whose ζ-potential has a magnitude larger than that of the wall, referred to as "type 2" particles, as well as to report findings on particles that appear to still be under the influence of the linear electrophoretic regime even at extremely high electric fields (∼6000 V/cm), referred to as "type 3" particles. Our findings suggest that both particle size and charge are key parameters in the determination of nonlinear electrophoretic properties. Type 2 microparticles were all found to be small (diameter ∼ 1 µm) and highly charged, with ζ-potentials above -60 mV; in contrast, type 3 microparticles were all large with ζ-potentials between -40 and -50 mV. However, it was also hypothesized that other nonconsidered parameters could be influencing the results, especially at higher electric fields (>3000 V/cm). The present work also aims to identify the current limitations in the experimental determination of µEP,NL and propose a framework for future work to address the current gaps in the evolving topic of nonlinear electrophoresis of colloidal particles.

Dependence of Nonlinear Electrophoresis on Particle Size and Electrical Charge.

This study focuses on the dependence of nonlinear electrophoretic migration of particles on the particle size and particle electrical charge. This is the first report of the experimental assessment of the mobilities of the nonlinear electrophoretic velocity of colloidal polystyrene microparticles under two distinct electric field dependences. A total of nine distinct types of polystyrene microparticles of varying size and varying electrical charge were divided into two groups to study separately the effects of particle size and the effects of particle charge. The mobilities of the nonlinear electrophoretic velocity of each particle type were determined in both the cubic and 3/2 regimes (µEP,NL(3) and µEP,NL(3/2)). The results unveiled that both mobilities had similar relationships with particle size and charge. The magnitude of both µEP,NL(3) and µEP,NL(3/2) increased with increasing particle size and decreased with increasing magnitude of particle charge. However, the observed trends were not perfect as discussed in the Results and Discussion section but still provide valuable information. These findings will aid in the design of future size-based and charge-based separations of particles and microorganisms.

Separation of Cells and Microparticles in Insulator-Based Electrokinetic Systems.

Presented here is the first continuous separation of microparticles and cells of similar characteristics employing linear and nonlinear electrokinetic phenomena in an insulator-based electrokinetic (iEK) system. By utilizing devices with insulating features, which distort the electric field distribution, it is possible to combine linear and nonlinear EK phenomena, resulting in highly effective separation schemes that leverage the new advancements in nonlinear electrophoresis. This work combines mathematical modeling and experimentation to separate four distinct binary mixtures of particles and cells. A computational model with COMSOL Multiphysics was used to predict the retention times (tR,p) of the particles and cells in iEK devices. Then, the experimental separations were carried out using the conditions identified with the model, where the experimental retention time (tR,e) of the particles and cells was measured. A total of four distinct separations of binary mixtures were performed by increasing the level of difficulty. For the first separation, two types of polystyrene microparticles, selected to mimic Escherichia coli and Saccharomyces cerevisiae cells, were separated. By leveraging the knowledge gathered from the first separation, a mixture of cells of distinct domains and significant size differences, E. coli and S. cerevisiae, was successfully separated. The third separation also featured cells of different domains but closer in size: Bacillus cereus versus S. cerevisiae. The last separation included cells in the same domain and genus, B. cereus versus Bacillus subtilis. Separation results were evaluated in terms of number of plates (N) and separation resolution (Rs), where Rs values for all separations were above 1.5, illustrating complete separations. Experimental results were in agreement with modeling results in terms of retention times, with deviations in the 6-27% range, while the variation between repetitions was between 2 and 18%, demonstrating good reproducibility. This report is the first prediction of the retention time of cells in iEK systems.